Drivetrain Questions and info regarding transmissions, clutches, etc.

Transmission removal/ installation help!

  #1  
Old 01-11-2007, 12:32 AM
turbonetics-g's Avatar
Registered User
Thread Starter
iTrader: (8)
Join Date: Jul 2006
Location: Northern Virginia
Posts: 413
Likes: 0
Received 0 Likes on 0 Posts
Transmission removal/ installation help!

Im planning to replace my tranny next weekend.
Where can i find step by step removal/installation guides online?
if anyone can help please post
 
  #2  
Old 01-11-2007, 12:41 AM
Klubbheads's Avatar
Registered User
iTrader: (10)
Join Date: Oct 2003
Location: LA, North Holly
Posts: 17,039
Likes: 0
Received 14 Likes on 11 Posts
what is stillen TS1?
 
  #3  
Old 01-11-2007, 02:37 AM
turbonetics-g's Avatar
Registered User
Thread Starter
iTrader: (8)
Join Date: Jul 2006
Location: Northern Virginia
Posts: 413
Likes: 0
Received 0 Likes on 0 Posts
Originally Posted by Klubbheads
what is stillen TS1?
stillen exhaust
TS1.... topsecret bumper replica
 
  #4  
Old 01-11-2007, 04:06 AM
2slo2bfurious's Avatar
Florida G35 Club, General Member
iTrader: (5)
Join Date: Nov 2003
Location: Broward
Posts: 1,335
Likes: 0
Received 2 Likes on 2 Posts
Just get a service manual, it has all the step by steps in there.

Here, looked it up for you, this is for 6mt though.

REMOVAL
1. Disconnect battery negative cable.
3. Remove catalytic converter stay mounting nuts and bolts, and
then remove catalytic converter bracket. Refer to EX-3,
"Removal and Installation" .
4. Remove nut connecting catalytic converter to exhaust manifold, and then remove catalytic converter and
exhaust front tube as one unit.
5. Remove propeller shaft. Refer to PR-7, "Removal and Installation"
CAUTION:
Do not impact or damage propeller shaft tube.
6. Remove control rod mounting bolts and then separate shift lever
assembly from the control rod assembly.
7. Use a screwdriver wrapped in tape to remove claw and then
separate console finisher from the center console. Refer to IP-
12, "Removal and Installation" .
8. Remove hole cover mounting bolts and then separate hole
cover from the floor panel.
9. separate control lever boot from the guide plate.
10. Remove guide plate mounting bolts and then separate shift lever
assembly from the shift lever housing assembly.

***6-10 not really needed, just take off the shifter and boot.

11. Remove clutch operating cylinder mounting bolts and then separate
clutch operating cylinder from the transmission case.
12. Remove POS sensor.
CAUTION:
 Do not subject it to impact by dropping or hitting.
 Do not disassemble.
 Do not allow metal filings, etc., to get on the sensor's
front edge magnetic area.
 Do not place in an area affected by magnetism.
13. Disconnect neutral switch and reverse switch.
14. Separate heated oxygen sensor 2 wire harness, POS sensor
wire harness, back-up lamp switch wire harness, PNP switch
wire harness from the transmission.
15. Remove starter motor. Refer to SC-18, "Removal and Installation" .
16. Set jack to the transmission.
CAUTION:
When setting jack, be careful not to contact with the switch.
17. Remove rear member. Refer to EM-89, "Removal and Installation"
.
18. Remove engine and transmission mounting bolts with power
tool.
19. Remove transmission from the vehicle.
 

Last edited by 2slo2bfurious; 01-11-2007 at 04:26 AM.
  #5  
Old 01-11-2007, 03:07 PM
turbonetics-g's Avatar
Registered User
Thread Starter
iTrader: (8)
Join Date: Jul 2006
Location: Northern Virginia
Posts: 413
Likes: 0
Received 0 Likes on 0 Posts
WOW.... very helpful thanks so much!
 
  #6  
Old 11-16-2011, 12:39 AM
blAk mAx's Avatar
Registered User
iTrader: (4)
Join Date: Oct 2007
Location: o-town & west palm beach FL
Posts: 5,267
Received 354 Likes on 214 Posts
How long should this take?
 
  #7  
Old 11-16-2011, 11:41 AM
Z1Motorsports's Avatar
Banned
iTrader: (8)
Join Date: Jan 2007
Location: Carrollton, GA
Posts: 2,383
Received 69 Likes on 55 Posts
Originally Posted by blAk mAx
How long should this take?
Depends on experience, a typical clutch job can take a first-timer 8-12hours. In our shop we typically knock out a clutch/flywheel kit in under 4.

-Rob
 
  #8  
Old 11-20-2011, 04:26 PM
Wrathernaut's Avatar
Gentle Manne of Leisure

iTrader: (5)
Join Date: Nov 2008
Location: Pennsylvania
Posts: 7,944
Received 1,036 Likes on 609 Posts
I just did mine with some help - 6 hours with a lift.

Non-typical tools I had to use:
T55 bit (flywheel bolts)
2 foot long extension + 1 foot long extension (reach the upper bell housing bolts)
Slide hammer (pilot bearing/bushing removal)
Hydraulic press (throwout bearing removal/installation)
Trans jack (obvious)
2 foot long breaker bar (bellhousing bolts)
Brass bar (pilot bearing/bushing installation)
Burly guy {to help join trans and engine back together}

Everything else was pretty typical mechanics tools - sockets, wobbles, extensions.
 
Related Topics
Thread
Thread Starter
Forum
Replies
Last Post
madmax032
Drivetrain
8
01-18-2016 10:41 AM
k67p67
Engine - Power Adders
0
08-29-2015 08:19 PM
sinasajadi
G35 Cars
4
08-26-2015 04:12 AM
saskicker32
Engine, Drivetrain & Forced-Induction
0
08-11-2015 02:12 PM
newg37
G35 Coupe V35 2003 - 07
1
07-26-2015 09:32 AM


Thread Tools
Search this Thread
Rate This Thread
Rate This Thread:
You have already rated this thread Rating: Thread Rating: 0 votes,  average.

Quick Reply: Transmission removal/ installation help!



All times are GMT -4. The time now is 09:42 AM.